Connecting IRLP node to mobile transceiver
IRLP Node number 4214 has employed different VHF/UHF transceivers, beginning with a somewhat unreliable Yaesu FT-7100M and moving on to a Yaesu FT-8000R. Several people have asked how I connected these radios to the node PC. Devising a suitable cable should be well within the capabilities of any radio amateur, but if you would like to see my particular method then here goes.
RS part number: 26-149, 6 ft extension cord for keyboard or mouse.
Cut off female end.
After cutting the cable, check which colored wire is connected to which pin using an ohmmeter. The table and diagram below show the cable colors for the Radio Shack extension keyboard / mouse cable that I used but your colors might be different!
Here are the connections required between the transceiver's 6-pin mini-DIN connector, the 1/8" stereo plugs for the Line In/Out jacks on the computer's sound card and the DB-9 female connector that runs to the IRLP Interface Board in the PC.
The diagram below shows how I connected my cables. The block marked "Interconnect" uses a Radio Shack # 274-679 12-position European-style terminal strip (aka choc-block connector), but you could also use a barrier strip or terminal strip to solder the connections.
As in any project combining low level audio and radio frequency transmission, be sure to connect all cable shields to "GND". The left and right audio wires in each of the 1/8" stereo cables are soldered together (red and black). The PTT line runs through an on-off switch so the transceiver does not come on at PC power-up. This is also a convenient place to disable the transmitter for testing etc.
Use of the standardized 6-pin mini-DIN packet connector makes it relatively easy to change from one mobile VHF/UHF transceiver to another. But if you do change transceiver, don't be surprised if the audio levels you need to set on the sound card are quite different from before. In some radios, the PKD "packet audio" is applied directly to the FM modulator without any filtering or limiting.
- 73 de Malcolm, NM9J, Sept 6 2004
G3VNQ-NM9J amateur radio site, 05-Jun-2007